مهندسی مکانیک مدرس

مهندسی مکانیک مدرس

تحلیل ترمودینامیک یک سیستم نوین ترکیبی چرخه‌های دی‌اکسید کربن گذر بحرانی و کالینا 11 ازچاه‌های زمین‌گرمایی سبلان

نوع مقاله : پژوهشی اصیل

نویسندگان
گروه مهندسی مکانیک، دانشکده فنی و مهندسی، دانشگاه ارومیه، ارومیه، ایران
چکیده
در شمال غرب ایران در منطقه سبلان دو چاه با شرایط دمایی و فشاری متفاوت مورد بهره‌برداری قرار گرفته است. با توجه به مشخصات ترمودینامیک چاه‌ها، چرخه‌ ترکیبی جدید (چرخه ترکیبی تبخیر آنی با چرخه دی‌اکسید کربن گذر بحرانی و کالینا۱۱) برای زمین‌گرمایی سبلان پیشنهاد شده است. در چرخه‌های کالینا ۱۱ و گذر بحرانی دی‌اکسید کربن داخل مبدل‌های حرارتی که سیال در حال افزایش دما است شیب تغییر دمایی متفاوتی دارد، بنابراین یک روش جدید برای پیداکردن محل نقطه تنگش و سایر مشخصات ترمودینامیک مبدل پیشنهاد شده است. تاثیر نسبت به فشار بالای کالینا، غلظت آمونیاک، نسبت فشار چرخه گذر بحرانی دی‌اکسید کربن، اختلاف دمای نقاط تنگش و فشار جداسازها روی بازده حرارتی و اگزرژی چرخه ترکیبی پیشنهادی مورد مطالعه قرار گرفت، سپس چرخه‌ ترکیبی پیشنهادی مورد بهینه‌سازی ترمودینامیک با استفاده از نرم‌افزار ای‌ای‌اس (حل معادلات مهندسی) قرار گرفت. براساس شرایط عملکرد بهینه، توان خالص چرخه ترکیبی ۲۰۰۴۶کیلووات، بازده حرارتی ۱۷/۱۵%، تخریب اگزرژی ۸۲۵۹کیلووات و بازده اگزرژی ۶۵/۷۴% محاسبه شده است. مشخص شده که برای چرخه‌ پیشنهادی در این مقاله توان خالص تولیدی ۱۷/۵۵%، بازده حرارتی ۱۷/۵۵% و بازده اگزرژی برای چرخه ترکیبی ۲۰/۰۴% نسبت به چرخه‌های پیشنهادی قبلی ارتقا یافته است.

کلیدواژه‌ها

موضوعات


عنوان مقاله English

The thermodynamic analysis of a novel integrated transcritical CO2 with Kalina 11 cycles from Sabalan geothermal wells

نویسندگان English

M. Abdolalipouradl
Sh. Khalilarya
S. Jafarmadar
Mechanical Engineering Department, Engineering Faculty, Urmia University, Urmia, Iran
چکیده English

In northwestern Iran, two wells with different temperature and pressure conditions have been exploited in Sabalan region. According to the thermodynamic properties of wells, the combined cycle (flash combined cycle with transcritical CO2 and Kalina 11) is proposed for Sabalan geothermal. In the Kalina 11 and transcritical CO2 heat exchangers, in which the fluid temperature is rising, there is a different temperature variation gradient, therefore, a new method is proposed for the determination of pinch point and other thermodynamic properties. The effects of the Kalina high pressure, amoina concentration, transcritical CO2 cycle pressure ratio, pinch points temperature difference and separators’ pressure on the thermal and exergy efficiencies of the proposed combined cycle were studied, Finally the proposed combined cycle was optimized thermodynamically using the EES (Engineering Equation Solver) software. Based on identical operation conditions, the net power of the combined cycle is 20046 kW, the thermal efficiency is 17.15%, the rate of exergy destructions is 8259 kW and the exergy efficiency is 65.74%. It was found that the net power output, the thermal and exergy efficiencies of combined cycle are about 17.55%, 17.55% and 18.35% higher than the previously proposed system.

کلیدواژه‌ها English

Thermodynamic Analysis
Sabalan Geothermal Power Plant
Kalina 11
Transcritical CO2 Cycle
Hung TC, Shai TY, Wang SK. A review of Organic Rankine Cycles (ORCs) for the recovery of low-grade waste heat. Energy. 1997;22(7):661-667. [Link] [DOI:10.1016/S0360-5442(96)00165-X]
Aneke M, Agnew B, Underwood C. Performance analysis of the Chena binary geothermal power plant. Applied Thermal Engineering. 2011;31(10):1825-1832. [Link] [DOI:10.1016/j.applthermaleng.2011.02.028]
Yari M. Exergetic analysis of various types of geothermal power plants. Renewable Energy. 2010;35(1):112-121. [Link] [DOI:10.1016/j.renene.2009.07.023]
Badr O, O'Callaghan PW, Probert SD. Rankine-cycle systems for harnessing power from low-grade energy sources. Applied Energy. 1990;36(4):263-292. [Link] [DOI:10.1016/0306-2619(90)90002-U]
Valdimarsson P, Eliasson L. Factors influencing the economics of the Kalina power cycle and situations of superior performance. Proceedings of the International Geothermal Conference, 14-17 Sep, 2003, Reykjavik, Island. Iceland: Geothermal Association of Iceland; 2003. p. 32-40. [Link]
Bombarda P, Invernizzi CM, Pietra C. Heat recovery from diesel engines: A thermodynamic comparison between Kalina and ORC cycles. Applied Thermal Engineering. 2010;30(2-3):212-219. [Link] [DOI:10.1016/j.applthermaleng.2009.08.006]
Madhawa Hettiarachchi HD, Golubovic M, Worek WM, Ikegami Y. The performance of the Kalina Cycle System 11(KCS-11) with low-temperature heat sources. Journal of Energy Resources Technology. 2007;129(3):243-247. [Link] [DOI:10.1115/1.2748815]
Li X, Zhang Q, Li X. A Kalina cycle with ejector. Energy. 2013;54:212-219. [Link] [DOI:10.1016/j.energy.2013.03.040]
Shokati N, Ranjbar F, Yari M. Exergoeconomic analysis and optimization of basic, dual-pressure and dual-fluid ORCs and Kalina geothermal power plants: A comparative study. Renewable Energy. 2015;83:527-542. [Link] [DOI:10.1016/j.renene.2015.04.069]
Vélez F, Segovia J, Chejne F, Antolín G, Quijano A, Carmen Martín M. Low temperature heat source for power generation: Exhaustive analysis of a carbon dioxide transcritical power cycle. Energy. 2011;36(9):5497-5507. [Link] [DOI:10.1016/j.energy.2011.07.027]
Yari M, Mehr AS, Zare V, Mahmoudi SMS, Rosen MA. Exergoeconomic comparison of TLC (trilateral Rankine cycle), ORC (Organic Rankine Cycle) and Kalina cycle using a low grade heat source. Energy. 2015;83:712-722. [Link] [DOI:10.1016/j.energy.2015.02.080]
Coskun A, Bolatturk A, Kanoglu M. Thermodynamic and economic analysis and optimization of power cycles for a medium temperature geothermal resource. Energy Conversion and Management. 2014;78:39-49. [Link] [DOI:10.1016/j.enconman.2013.10.045]
Rodríguez CEC, Palacio JCE, Venturini OJ, Silva Lora EE, Cobas VM, Dos Santos DM, et al. Exergetic and economic comparison of ORC and Kalina cycle for low temperature enhanced geothermal system in Brazil. Applied Thermal Engineering. 2013;52(1):109-119. [Link] [DOI:10.1016/j.applthermaleng.2012.11.012]
Fallah M, Mahmoudi SMS, Yari M, Akbarpour Ghiasi R. Advanced exergy analysis of the Kalina cycle applied for temperature enhanced geothermal system. Energy Conversion and Management. 2016;108:190-201. [Link] [DOI:10.1016/j.enconman.2015.11.017]
Jalilinasrabady S, Itoi R, Valdimarsson P, Saevarsdottir G, Fujii H. Flash cycle optimization of Sabalan geothermal power plant employing exergy concept. Geothermics. 2012;43:75-82. [Link] [DOI:10.1016/j.geothermics.2012.02.003]
Ameri M, Amanpour S, Amanpour S. Energy and exergy analysis and optimization of a double flash power plant for Meshkin Shahr region. World Renewable Energy Congress, 8-13 May, 2011, Linköping, Sweden. Linköping: Linköping University Electronic Press; 2011. p. 1297-1304. [Link] [DOI:10.3384/ecp110571297]
Aali A, Pourmahmood N, Zare V. Proposal and analysis of a new cycle for power generation from Sabalan geothermal wells. Journal of Mechanical Engineering of Tabriz University. 2017;47(3):139-147. [Persian] [Link]
Aali A, Pourmahmood N, Zare V. Exergoeconomic analysis and multi-objective optimization of a novel combined flash-binary cycle for Sabalan geothermal power plant in Iran. Energy Conversion and Management. 2017;143:377-390. [Link] [DOI:10.1016/j.enconman.2017.04.025]
Cengel YA, Boles MA. Thermodynamics: An engineering approach. 7th Edition. New York: McGraw-Hill; 2011. [Link]
Bejan A, Tsatsaronis G, Moran M. Thermal design and optimization. New York: John Wiley & Sons; 1996. pp. 113-160. [Link]
Klein SA, Alvarda SF. Engineering Equation Solver (EES) [Internet]. Madison: F-chart software; 2007 [cited 2018 May 01]. Available from: http://www.fchart.com/ees/mastering-ees.php. [Link]
Elsayed A, Embaye M, AL-Dadah R, Mahmoud S, Rezk A. Thermodynamic performance of Kalina Cycle System 11 (KCS11): Feasibility of using alternative zeotropic mixtures. International Journal of Low-Carbon Technologies. 2013;8(S1):i69-i78. [Link] [DOI:10.1093/ijlct/ctt020]